Dimethyl Ether Carbonylation on H-MOR Zeolite, Modified Cu, Co, Mg

Мұқаба

Дәйексөз келтіру

Толық мәтін

Ашық рұқсат Ашық рұқсат
Рұқсат жабық Рұқсат берілді
Рұқсат жабық Тек жазылушылар үшін

Аннотация

Mordenite and ferrierite (Zeolyst International, H-form, SiO2/Al2O3 ≈ 20) were used to study the adsorption, thermally programmed desorption, and carbonylation of dimethyl ether (DME). The behavior of mordenite with Cu, Co, and Mg cations introduced by ion exchange has also been studied. DME carbonylation was carried out at 200°C, pressure 3 MPa, space velocity 8000 ml g–1 h–1 in a mixture, vol. %: ⁓2.2 DME, 92.8–95.5 CO, rest. N2. After the induction period, the methyl acetate content is about 4–5 times higher for mordenite compared to ferrierite. The formation of water, methanol and hydrocarbons was observed in small quantities. The introduction of Cu, Co, Mg cations into mordenite by ion exchange (single ion exchange, cation/Al ratio no more than 35%) not only increased the stability, but also increased the activity in the DME carbonylation reaction. It was found that an increase in the content of copper (from 1.19 to 2.23 wt %) and Mg (from 0.62 to 1.8 wt %) differently affects the activity. In the case of copper, an increase in activity was observed, while in the case of magnesium, the activity decreased. Preliminary reduction of copper-exchange mordenite leads to a decrease in activity and the appearance of metallic copper particles on the surface of mordenite crystallites. According to in situ diffuse reflectance infrared spectroscopy, the introduction of magnesium cations by triple ion exchange leads to a noticeable decrease in the number of Brønsted acid sites (BACs) in both the 12-MR and 8-MR channels of mordenite. The catalytic characteristics of ferrierite practically do not change when copper and magnesium are introduced by ion exchange.

Авторлар туралы

M. Kipnis

Topchiev Institute of Petrochemical Synthesis, Russian Academy of Sciences

Хат алмасуға жауапты Автор.
Email: kipnis@ips.ac.ru
Russia, 119991, Moscow, Leninsky prosp., 29

R. Galkin

Topchiev Institute of Petrochemical Synthesis, Russian Academy of Sciences

Email: kipnis@ips.ac.ru
Russia, 119991, Moscow, Leninsky prosp., 29

E. Volnina

Topchiev Institute of Petrochemical Synthesis, Russian Academy of Sciences

Email: kipnis@ips.ac.ru
Russia, 119991, Moscow, Leninsky prosp., 29

I. Belostotskii

Topchiev Institute of Petrochemical Synthesis, Russian Academy of Sciences

Email: kipnis@ips.ac.ru
Russia, 119991, Moscow, Leninsky prosp., 29

G. Bondarenko

Topchiev Institute of Petrochemical Synthesis, Russian Academy of Sciences

Email: kipnis@ips.ac.ru
Russia, 119991, Moscow, Leninsky prosp., 29

O. Arapova

Topchiev Institute of Petrochemical Synthesis, Russian Academy of Sciences

Email: kipnis@ips.ac.ru
Russia, 119991, Moscow, Leninsky prosp., 29

Әдебиет тізімі

  1. Cheung P., Bhan A., Sunley G.J., Iglesia E. // Angew. Chem. 2006. V. 118. P. 1647.
  2. Bhan A., Allian A.D., Sunley G.J., Law D.J., Iglesia E. // J. Am. Chem. Soc. 2007. V. 129. P. 4919.
  3. Волнина Э.А., Кипнис М.А., Хаджиев С.Н. // Нефтехимия. 2017. Т. 57. № 3. С. 243. (Volnina E.A., Kipnis M.A., Khadzhiev S.N. // Petrol. Chem. 2017. V. 57. № 5. P. 353.).
  4. Кипнис М.А., Волнина Э.А. // Кинетика и катализ. 2022. Т. 63. С. 147. (Kipnis M.A., Volnina E.A. // Kinet. Catal. 2022. V. 63. Р. 129).
  5. Zhan E., Xiong Z., Shen W. // J. Energy Chem. 2019. V. 36. P. 51.
  6. Le T.T., Chawla A., Rimer J.D. // J. Catal. 2020. V. 391. P. 56.
  7. Alberti A. // Zeolites. 1997. V. 19. P. 411.
  8. Simoncic P., Armbruster T. // Am. Mineral. 2004. V. 89. P. 421.
  9. Kerr I.S. // Nature. 1966. V. 210. P. 294.
  10. Wang S., Guo W., Zhu L., Wang H., Qiu K., Cen K. // J. Phys. Chem. C. 2015. V. 119. P. 524.
  11. Li Y., Huang S., Cheng Z., Wang S., Ge Q., Ma X. // J. Catal. 2018. V. 365. P. 440.
  12. Cheng Z., Huang S., Li Y., Cai K., Yao D., Lv J., Wang S., Ma X. // Appl. Catal. A: Gen. 2019. V. 576. P. 1.
  13. Zhan H., Huang S., Li Y., Lv J., Wang S., Ma X. // Catal. Sci. Technol. 2015. V. 5. P. 4378.
  14. Reule A.A.C., Semagina N. // ACS Catal. 2016. V. 6. P. 4972.
  15. Reule A.A.C., Prasad V., Semagina N. // Micropor. Mesopor. Mater. 2018. V. 263. P. 220.
  16. Blasco T., Boronat M., Concepcion P., Corma A., Law D., Vidal-Moya J.A. // Angew. Chem. Int. Ed. 2007. V. 46. P. 3938.
  17. Ma M., Zhan E., Huang X., Ta N., Xiong Z., Bai L., Shen W. // Catal. Sci. Technol. 2018. V. 8. P. 2124.
  18. Xu F., Hong Z., Lv J., Chen C., Zhao G., Miao L., Yang W., Zhu Z. // Appl. Catal. A: Gen. 2022. V. 648. 118928.
  19. Кипнис М.А., Самохин П.В., Яшина О.В., Сухореброва О.А. // Журн. физ. химии. 2013. Т. 87. С. 868. (Kipnis M.A., Samokhin P.V., Yashina O.V., Sukhorebrova O.A. // Rus. J. Phys. Chem. A. 2013. V. 87. № 5. P. 851.).
  20. Кипнис М.А., Белостоцкий И.А., Волнина Э.А., Лин Г.И., Маршев И.И. // Кинетика и катализ. 2018. Т. 59. № 6. С. 715. Kipnis M.A., Belostotskii I.A., Volnina E.A., Lin G.I., Marshev I.I. // Kinet. Catal. 2018. V. 59. P. 754.).
  21. Самохин П.В., Белостоцкий И.А., Маршев И.И., Кипнис М.А. // Журн. аналит. химии. 2019. Т. 74. № 9. С. S21. (Samokhin P.V., Belostotskii I.A., Marshev I.I., Kipnis M.A. // J. Anal. Chem. 2019. V. 74. Suppl. 2. P. S17.).
  22. Rasmussen D.B., Christensen J.M., Temel B., Studt F., Moses P.G., Rossmeisl J., Riisager A., Jensen A.D. // Catal. Sci. Technol. 2017. V. 7. P. 1141.
  23. Feng P., Zhang G., Chen X., Zang K., Li X., Xu L. // Appl. Catal. A: Gen. 2018. V. 557. P. 119.
  24. Kim E.J., Gao X., Tian J., Bae J.W. // Catal. Today. 2023. V. 411–412. 113822.
  25. Cherkasov N., Vazhnova T., Lukyanov D.B. // Vib. Spectrosc. 2016. V. 83. P. 170.
  26. Литтл Л. Инфракрасные спектры адсорбированных молекул. Пер. с англ. М.: Мир, 1969. 514 с. (Little L.H. Infrared spectra of adsorbed species. London-New York: Academic Press, 1966. 428 p.)
  27. Theivasanthi T., Alagar M. // Arch. Phys. Res. 2010. V. 1. № 2. P. 112.
  28. Reule A.A.C., Shen J., Semagina N. // ChemPhysChem. 2018. V. 19. P. 1500.

Қосымша файлдар